Hi Freel2ers,

Can anyone shed any light on the above issue. Prior to carrying out the replacement of the EGR valve and cooler the car run smoothly. Following the replacement I have an engine hunting problem on tickover. As the car is an auto it occasionally makes reversing interesting when it revs just when you don't want it to!

I fitted a Lucas EGR and had a local specialist sync it to the car but the hunting issue has persisted.

There is one weird thing that makes the car tickover normally and that is disconnecting the MAF sensor. When it is disconnected the car runs and drives smoothly but if it is reconnected the hunting returns. I have bought and replaced the MAF sensor and the new one made no difference to the hunting problem when connected but all was fine with it disconnected. Obviously I can't keep it disconnected as the engine management light is on.

Any ideas as to how I can resolve this problem would be gratefully appreciated.

I think ???? I read on here somewhere that a new MAF sensor has to be calibrated? 2013 FL2 XS.
Defender 90 300 TDi.
Defender 90 300 TDi CSW.
1964 MGB Roadster.
1944 Willys MB "Jeep" with bullet holes. (gone)
17 hand Irish Drought Thoroughbred (mostly lame)
Nagging Old Boiler.

Mahatma Gandhi said if there is an Idiot in power those who elected him are well represented

It sounds like it needs an air path calibration be done. The EGR system is disabled if the MAF doesn't return a signal. Hyundai Ioniq 5 Ultimate. The family car.
2009 Rimini Red SE TD4. Gone.
2006 Tonga Green i6 HSE. Gone.
Audi A5 convertible, my daily driver.
1972 Hillman Avenger GT, the project.

Thank you Rommel and Nodge68! I have booked it in with my local independent garage (early Nov) and will take along these responses. Very grateful for the replies and I will update this post with the outcome.

Good Luck  2013 FL2 XS.
Defender 90 300 TDi.
Defender 90 300 TDi CSW.
1964 MGB Roadster.
1944 Willys MB "Jeep" with bullet holes. (gone)
17 hand Irish Drought Thoroughbred (mostly lame)
Nagging Old Boiler.

Mahatma Gandhi said if there is an Idiot in power those who elected him are well represented